Skip to main content
  • Research article
  • Open access
  • Published:

Exploitation of algal-bacterial associations in a two-stage biohydrogen and biogas generation process

Abstract

Background

The growing concern regarding the use of agricultural land for the production of biomass for food/feed or energy is dictating the search for alternative biomass sources. Photosynthetic microorganisms grown on marginal or deserted land present a promising alternative to the cultivation of energy plants and thereby may dampen the ‘food or fuel’ dispute. Microalgae offer diverse utilization routes.

Results

A two-stage energetic utilization, using a natural mixed population of algae (Chlamydomonas sp. and Scenedesmus sp.) and mutualistic bacteria (primarily Rhizobium sp.), was tested for coupled biohydrogen and biogas production. The microalgal-bacterial biomass generated hydrogen without sulfur deprivation. Algal hydrogen production in the mixed population started earlier but lasted for a shorter period relative to the benchmark approach. The residual biomass after hydrogen production was used for biogas generation and was compared with the biogas production from maize silage. The gas evolved from the microbial biomass was enriched in methane, but the specific gas production was lower than that of maize silage. Sustainable biogas production from the microbial biomass proceeded without noticeable difficulties in continuously stirred fed-batch laboratory-size reactors for an extended period of time. Co-fermentation of the microbial biomass and maize silage improved the biogas production: The metagenomic results indicated that pronounced changes took place in the domain Bacteria, primarily due to the introduction of a considerable bacterial biomass into the system with the substrate; this effect was partially compensated in the case of co-fermentation. The bacteria living in syntrophy with the algae apparently persisted in the anaerobic reactor and predominated in the bacterial population. The Archaea community remained virtually unaffected by the changes in the substrate biomass composition.

Conclusion

Through elimination of cost- and labor-demanding sulfur deprivation, sustainable biohydrogen production can be carried out by using microalgae and their mutualistic bacterial partners. The beneficial effect of the mutualistic mixed bacteria in O2 quenching is that the spent algal-bacterial biomass can be further exploited for biogas production. Anaerobic fermentation of the microbial biomass depends on the composition of the biogas-producing microbial community. Co-fermentation of the mixed microbial biomass with maize silage improved the biogas productivity.

Introduction

Biomass utilization for energy generation is commonly regarded as a major contributor to the achievement of renewable energy production targets [1-4]. Energy carriers from biomass are currently predominantly produced through the use of terrestrial plants [5]. The intensive exploitation of land for the cultivation of crops destined for biofuel production, however, may exert a negative impact on the global supply and the price of food and feed [6].

The search for alternative biomass sources still continues. Economically and environmentally friendly solutions should be found. Huge energetic and biorefinery opportunities are offered by the conversion of solar energy via the use of photosynthetic microorganisms. Hence, the interest in photosynthetic microorganisms (and especially microalgae) is growing worldwide. The microalgae are a large and diverse group of microscopic, photoautotrophic, or photoheterotrophic organisms, which grow profusely in both salt and fresh natural waters [7]. Microalgae are able to double their biomass much faster than terrestrial plants, and they therefore produce more biomass per hectare than higher plants do [8]. The relatively small land area needed to cultivate microalgae may be arable or marginal land, which further decreases the competition for agricultural land and smothers the ‘food or fuel’ dispute [7]. Microalgae can be harvested practically all year round, hence improving the biomass production efficacy and eliminating numerous storage problems. Cultivation is possible in closed photobioreactors or in open ponds. Open systems are usually considered to be economical, while closed systems are more efficient from the aspect of biomass production and control of the cultivation parameters [9,10]; either concept may therefore be competitive in diverse applications [11]. Additional beneficial features of a microalgal biomass include versatility and the variety of utilization for energetic purposes such as biohydrogen (bioH2), bioethanol, biodiesel, and biogas production [12-14], besides biorefinery applications [14-16].

The important properties of a microalgal biomass to be used in anaerobic digestion (AD) include high contents of lipids and/or carbohydrates and a lack of recalcitrant lignin [12]. The lipid and carbohydrate content amounts up to 50% of the biomass dry weight in some strains [10,17]. Research on the AD of algal biomass started more than 50 years ago [18]. Until recently, only a few studies followed up this line of research [19-24]. Levels of biogas productivity from various fresh and salt water algal strains have been compared under mesophilic conditions [25]. The biogas potential was found to depend strongly on the species and on the cell disruption method applied. The CH4 content of the gas evolved from the microalgae was 7% to 13% higher than that from maize silage [25]. A closed-loop system to convert the algal biomass to biogas and electricity has been tested [26]. The microbial communities thriving in anaerobic digesters fed with algal biomass have not been investigated extensively. The archaeal community formed during microalgal fermentation was recently analyzed by next-generation sequencing [27].

Some microalgae, such as the most extensively studied green microalga Chlamydomonas reinhardtii, have the noteworthy ability to produce H2 via a photosynthetic water-splitting reaction coupled with the dark hydrolysis of storage materials [28-30]. Sulfur deprivation becomes a standard method through which to switch the algal metabolism from photoautotrophy to dark heterotrophic H2 generation. The two-step process during which the cells undergo major metabolic and biochemical changes demands considerable energy input both by the process operators and by the algae.

Naturally formed, mixed algal-bacterial microbial communities have been observed to have beneficial effects on algal growth [31-34]. The mutualistic relationship involves supplying the algae with important growth factors, notably vitamin B12, by the bacterial partner in exchange for organic nutrients [35-39]. Little is known about H2 production by algal-bacterial systems [40]. A recent study proposed that by consuming the O2 generated photosynthetically by the algae, the bacteria maintain an anaerobic environment suitable for algal bioH2 production [41]. This may eliminate the need for the sulfur-deprivation step [28-30].

In this study, we modeled a two-stage biorefinery process, that is, H2 production in the first stage by an algal-bacterial mixed biomass grown under nonsterile photoheterotrophic conditions, with biogas generation from the residual biomass in the second stage. The composition of the microalgal-bacterial mixture was monitored during the process by using next-generation DNA sequencing technology.

Results and discussion

H2 production by the mixed algal-bacterial system

H2 accumulated in the reactor headspace and concomitantly O2 disappeared in time when a mixture of Scenedesmus sp. and Chlamydomonas sp. was cultivated under nonsterile conditions together with their natural mutualistic bacterial partners (AB + S culture), which consumed the O2 produced by the algae. The results were compared with the H2 evolution by a mixture of the pure cultures of the two microalgae supplemented with hydrogenase-deficient Escherichia coli cells (AE + S culture) and by sulfur-deprived, bacterium-free algal cultures (A-S culture) (Figure 1). Striking differences were observed in terms of accumulated H2 yields and the commencement and duration of H2 evolution.

Figure 1
figure 1

H 2 accumulation (A) and O 2 content (B) in the headspaces of the various cultures in time. Orange circles: mixed algal-bacterial co-culture (AB + S); green squares: algal-bacterial mixture with added E. coli ΔhypF (AE + S); blue triangles: sulfur-deprived bacterium-free co-culture of Chlamydomonas sp. and Scenedesmus sp. (A-S); red diamonds: bacterium-free co-culture of Chlamydomonas sp. and Scenedesmus sp. without sulfur deprivation (A + S).

In the headspace of the growing algal-bacterial culture, the O2 level decreased from 21% to 4.5% in 12 h (Figure 1B). The low O2 level allowed H2 evolution by the algal biomass after 8 h and 1.15 ± 0.09 mL H2 L−1 was produced during the next 16 h, confirming earlier observations in similar systems (Figure 1A) [41].

The mutualistic bacteria were eliminated from the algal culture by photoautotrophic cultivation on minimal medium supplemented with rifampicin. H2 production was not observed of the bacterium-free algal culture (A + S), because O2 was not consumed by the mutualistic bacteria and the biosynthesis of the O2 sensitive hydrogenases was repressed (Figure 1A,B). The facultative anaerobic wild-type E. coli tends to consume O2 when it is available. Under anaerobic conditions, E. coli evolves H2 by using its own hydrogenases [42]. In order to eliminate the contribution of H2 production by E. coli, a pleiotropic hydrogenase mutant (ΔhypF) strain was used in these experiments so that only the facultative anaerobic property of this bacterium is functioning. Addition of E. coli ΔhypF cells and acetate to the pure algal culture (AE + S) efficiently reduced the level of O2 from 21% to 4% in 2 h. Pronounced H2 production accompanied this condition (1.52 ± 0.04 mL H2 L−1) (Figure 1A). The bacterial cell number in the spontaneously formed algal-bacterial culture (AB + S) was markedly lower than in the algal-E. coli ΔhypF co-culture (AE + S), which may explain why H2 generation by the AE + S started earlier than without the O2 scavenger E. coli strain (Figure 1). These data were compared with the H2 production by the mixture of the pure algal strains using the photoheterotrophic TRIS-acetate-phosphate medium (TAP) and employing the sulfur-deprivation method [43,44]. The sulfur-deprived pure Scenedesmus sp. and Chlamydomonas sp. mixture (A-S culture) became anaerobic after 20 h as opposed to the 2 to 8 h in the case of AB + S and AE + S. H2 evolution starts when anaerobic conditions are established; therefore, the difference in time required to reach anaerobicity is critical for the efficacy of the process. Additional benefits from practical aspect are the lower cost of alga production under nonsterile conditions and the elimination of labor- and cost-intensive transfer of algae into the sulfur-deficient medium.

The highest level of H2 generation by the A-S (1.91 ± 0.12 mL H2 L−1) was reached after 4 days (Figure 1A), which exceeded the H2 production of the AE + S culture only by about 20%. In view of the exceptionally thick cell walls of the Scenedesmus strains, the H2 productivity may have been partly diffusion-limited in the mixed algal culture, which may explain the lower H2 yield of A-S relative to the pure culture of sulfur-deprived Chlamydomonas sp. 549 strain (2.63 ± 0.04 mL H2 L−1) reported earlier [41]. Taken together, these experiments demonstrated that algal-bacterial natural mutualistic consortia are superior to the bacterium-free sulfur-deprived algal cultures from the aspect of H2 evolution.

There are two possible reasons why the H2 production ceased after about 24 h in the algal-bacterial co-cultures cultivated in TAP medium (see the ‘Materials and methods’ section). First, the H2 yield depends on the H2 partial pressure in a closed system [45]. Removal of the product H2 from the headspace allows the extension of the production time, leading to sustainable H2 evolution (data not shown). Secondly, in separate experiments, we have demonstrated that the depletion of acetate also results in a rapid loss of the mutualistic bacteria [41]. This can be remedied by the systematic addition of acetic acid to the system. Acetate is a low-value commodity produced in a number of anaerobic fermentative processes. The limiting factors of this bioH2 production methodology appear to be relatively easy to overcome. H2 production by algae under nonsterile conditions may make this approach economically viable on a large scale.

Biogas production from algal-bacterial mixed biomass

The levels of biogas production from the various biomass substrates were determined after a 1-month of start-up and stabilization phase, that is, in weeks 1 to 4 of the experiment. During this time, the reactors were fed with the AB + S substrate to ensure that all the remaining and digestible biomass from the inoculum (containing pig slurry and maize silage) had been degraded and did not contribute to the biogas formation. Gas production data were collected during weeks 5 to 9, when the evolved gas was produced from the AB + S biomass. Biogas generation from the algal-bacterial mixture was compared with co-fermentaion of the alga-rich biomass and maize silage, and reactors fed with maize silage were used as controls. The CH4 concentration in the gas made from the AB + S biomass substrate was 58% to 61%, which is comparable to previous findings [25,26,46]. The biogas CH4 content from maize silage alone was 50% to 52%, as found previously [47]. The co-fermentation of algal-bacterial biomass with maize silage, in a ratio of 1:1, on the basis of organic dry matter (oDM), yielded a CH4 content of 54% to 57%, an intermediate value between those for maize silage and the algal-bacterial biomass. The daily average generated biogas volumes were as follows: from maize silage 3.20 L day−1, from co-fermentation 3.15 L day−1, and from algal-bacterial mixture 2.20 L day−1. Figure 2 shows the specific average CH4 production values (mL) calculated for g oDM−1.

Figure 2
figure 2

Specific CH 4 production from the various biomasses.

For the appreciation of the potential value of the AB + S biomass as biogas substrate, its advantages relative to the widely used maize silage have to be taken into account. Most importantly, the AB + S biomass can be cultivated under nonsterile conditions on lands not useful for agricultural production and can be continuously harvested during extended period of the year. Although several technical issues related to the large-scale production of AB + S biomass for energetic purpose remain to be elaborated, this material may effectively replace a large portion of maize silage in the biogas reactors.

VOAs/TAC ratio indicated stable operation

The ratio of the volatile organic acids (VOAs) and the total alkaline capacity (TAC) is an appropriate measure of the functional stability of the anaerobic digestion process [48,49]. A VOAs/TAC ratio below 0.1 means that the reactor needs feeding, whereas at a ratio ≥0.5 the biomass input is excessive and the process is out of balance. During the experiments, the average content of VOAs was 1.5 g L−1 and the average TAC was between 9 and 10 g CaCO3 L−1 in all cases. Figure 3 shows the weekly measured VOAs/TAC ratios.

Figure 3
figure 3

Weekly measured VOAs/TAC ratios. The area between the dashed red lines indicates the optimum range.

A constant value of VOAs/TAC is a reliable indicator of a stable fermentation process. The organic loading rate was on the low side and allowed stable and balanced operation.

NH4 + accumulation

From the decomposition of nitrogen-containing compounds, ammonia (NH3) is formed, which is present in the aqueous medium in the form of ammonium ion (NH4 +) [50]. Values above 3,000 mg NH4 + L−1 may have a negative effect on the methanogenic community [51,52]. During the anaerobic fermentation, slight fluctuations in the weekly NH4 + concentrations were observed. In the case of using the algal-bacterial mixture, the NH4 + content tended to increase but remained under the critical 3,000 mg NH4 + L−1 level (Figure 4). Co-fermentation efficiently balanced this elevated NH4 + level.

Figure 4
figure 4

Weekly measured NH 4 + concentrations. The dashed red line indicates the highest value recommended by the various studies.

The effect of the C/N ratio

The ideal C/N ratio for AD is 20 to 30 [53,54], because the microbes in the anaerobic reactor can utilize carbon (C) 20 to 30 times faster than nitrogen (N) [54]. The risk of C starvation increases if the C/N ratio is lower than 20; the methanogens are inhibited by the high NH3 accumulation, making the AD process vulnerable. At the other end of the spectrum, if the C/N ratio exceeds 30, the concentration of volatile fatty acids escalates, leading to process inhibition. The C/N ratios of the substrates used in this work are presented in Table 1. During the fed-batch continuous AD of microalgae and their mutualistic bacterial flora (AB + S), the nitrogen content increased. The initial C/N ratio of the AB + S biomass was low, 5.3. The nitrogen content increased as the fermentation progressed (Figure 5), accompanied by a slight but persistent free N concentration increase. Co-fermentation of the algal-bacterial biomass with maize silage, which had a C/N ratio of 45.3, led to a less pronounced N accumulation, indicating a buffering effect of the maize silage. In the reactors fed with maize silage alone, the N level remained nearly constant (Figure 5).

Table 1 The initial substrate compositions
Figure 5
figure 5

Changes in N content during the AD of various substrates. Green: AB + S, orange: co-fermentation, blue: maize silage.

Olsson et al. reported that feeding AD reactors with a high proportion of microalgal biomass in co-fermentation with waste water sludge had a negative effect under both thermophilic (55°C) and mesophilic (37°C) conditions, possibly because of the high N content of the microalgal biomass [55]. Co-fermentation of a microalgal biomass with waste paper improved the AD performance [56], presumably in consequence of the higher C/N ratio of the mixed substrate and the induction of cellulase biosynthesis by the paper sludge. In our case, co-fermentation of the algal-bacterial biomass with the cellulose-rich maize silage likewise enhanced the biogas productivity.

Microbial community

The composition of the microbial community was established at four time points: at the start of feeding with the selected substrate (start), 1 week later (week 1), when the system was working at full capacity (week 5), and at the end of the process (week 9). The microbial community compositions of the substrates were determined separately.

Microbiological compositions of the substrates

The microbial flora of the maize silage included representatives of the genera Lactobacillus and Acetobacter, as expected (Figure 6A). Lactobacilli produce lactate from mono- and disaccharides [57]. Upon ensilaging, the accumulating acid decreases the pH and preserves the green plant material. Members of the genus Acetobacter primarily contribute to acetate production [58].

Figure 6
figure 6

Microbial compositions of the substrates: (A) Maize silage, (B) AB + S. The communities at domain, phylum, class, and genus levels are indicated.

The mixture of Chlamydomonas sp. and Scenedesmus sp. microalgae was cultivated under nonsterile conditions and contained copious amounts of the mutualistic bacteria (Figure 6B). Rhizobium species predominated in the bacterial population. Rhizobium is well known for its syntrophic interaction with plants and mutualism has also been observed in the cases of several microalgal species [36,39]. The major probable driving force behind this association is vitamin B12, which the algae needs for growth but cannot synthesize. Rhizobium is there to supply the algae with vitamin B12 in exchange for fixed carbon. The growth rate and the resistance to environmental stresses improve as a result of the algal-bacterial interactions [36,39]. Other forms of mutualism between microalgae and bacteria have also been recognized [31-34].

The biogas-producing microbial community

The distribution of the microbial taxa in the biogas-producing microbial community at the beginning of the experiments was very similar to that found in earlier studies on reactors fed with pig manure and maize silage [59], in good agreement with starting the reactors with inocula from a mesophilic industrial biogas facility digesting such substrates. These results may therefore be regarded as an internal control validating the metagenome sequencing method. In the following detailed analysis of the metagenomic results, the unidentified sequences are disregarded.

Microbial community of maize silage AD (domain Bacteria)

Only relatively minor and trivial rearrangements occurred in the relative distribution of the bacterial taxa during the experimental period (Figure 7). This is not surprising in view of the fact that the reactors were sustained on pig manure and maize silage prior to the start of the experiment. In the domain Bacteria, the most abundant strains belong in the phylum Firmicutes. Pronounced changes were seen in the phylum Proteobacteria. Some of the Proteobacteria were apparently displaced by Firmicutes and Bacteroidetes. In the phylum Firmicutes, the orders Clostridiales and Bacteroidales predominated (Figure 8). Among the Clostridiales, the genus Clostridium increased in abundance, followed by the genus Bacillus. In the order Bacteroidales, the genus Bacteroides predominated (data not shown).

Figure 7
figure 7

Changes in the domain Bacteria of the microbial community at phylum level. (A) Maize silage, (B) co-fermentation, and (C) algal-bacterial biomass.

Figure 8
figure 8

Changes in the domain Bacteria of the microbial community at the order level. (A) Maize silage, (B) co-fermentation, and (C) algal-bacterial biomass.

Microbial community of co-fermentation (domain Bacteria)

Co-fermentation of the algal-bacterial mixture with maize silage provoked major changes in the composition of the bacterial community within a week as compared with the AD of maize silage (Figures 7 and 8). At the starting time point, there was no difference between the reactors fed with the various substrate compositions, indicating that the same microbial community was established during the start-up phase and the initial conditions were therefore identical. Supplying the reactors with a 1:1 mixture of microbial biomass and maize silage instigated a rearrangement within the biogas-producing microbial community. Representatives of the phylum Proteobacteria gradually predominated in the community, and within the taxon, the orders Rhizobiales and Burkholderiales prevailed (Figure 8). At higher resolution, a marked accumulation of the genera Rhizobium and Burkholderia was evident as the experiment progressed, although the phylum Proteobacteria displayed a diverse representation at the start. At the same time, members of the phylum Firmicutes and to a lesser degree those belonging to the phylum Bacteroidetes lost their significance within the AD community. The majority of bacteria belonging in these taxa have gained a reputation as outstanding cellulose degraders and H2 producers, both of these metabolic activities being crucial for efficient biogas production from plant biomass.

Microbial community of microalgal-bacterial fermentation (domain Bacteria)

A noteworthy fast response by the biogas-producing microbial community was observed when the substrate added to the reactors was changed from the mixture of pig slurry and maize silage to the algal-bacterial biomass. The reaction was less pronounced, but similar when the reactors were fed with a 1:1 mix of plant and microbial biomasses, as discussed above. The main outcome of this reorganization was the predominance of the phylum Proteobacteria, which surpassed the phyla Firmicutes and Bacteroidetes. The genera Rhizobium and Burkholderia were introduced into the reactor with the substrate (Figure 6) and accumulated in time (Figure 8), in spite of the relatively low daily organic loading rate. Either the decomposition was too slow to convert the total administered bacterial biomass to biogas, or the Rhizobia multiplied faster than their anaerobic degradation. Rhizobium species survive in free living form under anaerobic conditions, taking advantage of their nitrate respiration capability [60,61], but it is unlikely that their growth rate exceeds that of the anaerobic degradation by the biogas microbial community. The substrate was stored at −20°C for about 3 months before being fed into the reactors. It seems likely that the build-up of Proteobacteria in time is due to their relatively slow decomposition under the AD conditions. In this respect, it is noteworthy that the relative abundance of eukaryotic sequences in the reactors also increased in time (Figure 9). The eukaryotic DNA accumulation from the algal biomass was twice that from the maize, suggesting that the algal cell wall may be more resistant than that of the maize silage to microbial degradation.

Figure 9
figure 9

Eukaryotic sequences in the reactors. Green: AB + S, orange: co-fermentation, blue: maize silage.

This implies that the biogas potential of the algal biomass is higher than that of the bacterial biomass, although a correct mass balance is difficult to achieve because of the complexity of the organic materials in the reactor.

The domain Archaea

In the domain Archaea, a microbial composition was found that was distinct from those observed in previous studies in reactors fed with ‘conventional’ substrates [59,62-66]. The class Methanomicrobia represented the domain Archaea in great abundance. The Methanomicrobia are able to operate all three routes of methanogenesis [67]. The order Methanomicrobiales was the most prevalent from the start, and at higher resolution, the members of the genus Methanosarcina predominated. Seasonal changes or other uncontrolled factors may also be responsible for these alterations in the AD communities [68-70]. At any rate, the genus Methanosarcina remained predominant in all fermentations tested in this study (Figure 10). Interestingly, in a previous study, involving the use of next-generation sequencing mcrA genes, the order Methanosarcinales was also found to be predominant in the AD of a mixture of waste water sludge and a nonsterile, unidentified algal biomass [27]. In the Archaeal community converting that substrate to biogas, the acetotrophic genus Methanosaeta (order Methanosarcinales) was identified as the prevailing taxonomic unit. Members of the genus Methanosaeta were present in our study too, although in less abundance.

Figure 10
figure 10

Distribution of the domain Archaea in the microbial community at the order level. (A) Maize silage, (B) co-fermentation, and (C) algal-bacterial biomass.

Conclusions

A combination of bioH2 and biogas production by a mixture of nonsterile microalgae and natural bacterial flora was demonstrated. In a closed system, the mutualistic bacteria consumed the O2 evolved by the algae and created a sufficiently anaerobic environment for algal H2 evolution without damaging the photosynthetic apparatus of the algae. With the help of the bacterial partners, the algae succeeded in capturing light energy by photosynthetic water splitting and evolved H2 at the same time without the need for further manipulation of the system, such as sulfur deprivation.

H2 production through the use of a mixture of microalgae and syntrophic bacteria started earlier than the H2 evolution following sulfur deprivation, although sulfur-deprived C. reinhardtii produced bioH2 for a longer period of time.

AD and biogas evolution from the nonsterile microalgal-bacterial biomass yielded a gas enriched in CH4 relative to the commonly used maize silage. The specific biogas production estimated on the basis of the organic material input, however, was smaller than that from maize silage. The addition of maize silage to the algal-bacterial mixed biomass increased the C/N ratio considerably and improved the balanced digestibility of the microbial biomass.

The metagenome analysis of the microbial communities present in the AD reactors revealed the persisting impact of the microalgae and their bacterial companions on the composition of the AD microbial community within a few days. The large amount of bacteria belonging in the genera Rhizobium and Burkholderia, dosed together with the microalgal biomass, significantly changed the bacterial community composition. Co-fermentation of the algal-bacterial biomass with maize silage compensated somewhat for the Rhizobium and Burkholderia predominance due to the 50% lower loading of the microbial biomass on an organic dry matter basis. In the control reactors fed with maize silage, the microbial taxa belonging in the phyla Firmicutes and Bacteroidetes persisted.

Interestingly, the pronounced alterations observed in the domain Bacteria did not affect the composition of the domain Archaea. The order Methanosarcinales predominated in the Archaeal community regardless of the substrate composition.

Materials and methods

Cultivation of pure and mixed cultures

The Chlamydomonas sp. and Scenedesmus sp. algae and their mutualistic bacteria (AB + S culture) were obtained as algal strain 810 from the Mosonmagyaróvár Algal Culture Collection (MACC) of Hungary. The purified algal mixture was maintained and cultivated on TP (TRIS-phosphate) medium supplemented with rifampicin. The TP medium is a modified TAP (TRIS-Acetate-Phosphate) medium where acetate is replaced with HCl. The TAP and TP plates were incubated under 50 μmol m−2 s−1 light intensity at 25°C. Algae used for H2-evolution experiments were harvested as fresh cultures grown on TP-agar plates supplemented with rifampicin and transferred into liquid TAP medium [41,71,72]. The algal stock solutions were equally distributed into 40-mL Hypo-Vial bottles, resulting in a final volume of 35 mL and a final optical density (OD750) of 0.7. E. coli ΔhypF, a hydrogenase-deficient strain, was grown on LB (Luria-Bertani medium) plates at 30°C in the dark.

The original algal-bacterial culture, used for H2 production experiments, was pre-grown in TAP medium. The medium of the pre-grown stock culture was changed to fresh TAP medium by centrifugation. It was diluted to OD750 of 1.2. Bottles were sealed with butyl rubber stoppers and aluminum caps. All experiments were performed in at least three parallel repetitions.

Algal-bacterial culture scaling up for biomass production

For biomass production, an unpurified culture of a Scenedesmus sp. and Chlamydomonas sp. mixture, as obtained from the MACC collection, was cultivated in 13-L polycarbonate vessels under 50 μmol m−2 s−1 light intensity at 25°C for 5 days before harvesting. The biomass yield was approximately 2 g L−1. The microbial biomass was harvested by using a cross-flow centrifuge and the harvested biomass was stored at −20°C until utilization.

Gas chromatographic analyses

The H2 and O2 levels in the headspace of the Hypo-Vial bottles were measured by gas chromatography. An Agilent 7890A gas chromatograph (Agilent Technologies, Santa Clara, USA), equipped with a thermal conductivity detector and an Agilent HP-Molsieve column (length 30 m, diameter 0.320 mm, film 12.0 μm; Agilent Technologies, Santa Clara, USA) was used in splitless mode. Linde HQ argon 5.0 (Linde Group, Munich, Germany) was used as carrier and reference gas. The temperatures of the injector, TCD detector, and column were kept at 150°C, 160°C, and 60°C, respectively. The column pressure was 47.618 psi. The flow rate of the column was 12 mL min−1. Samples (50 μL) were analyzed. Three biological replicates were used for the measurements. A H2 calibration curve was used to determine accurate gas volumes. Serial dilutions of pure H2 gas were prepared in 25-mL gas-tight vials, and identical volumes were injected into the gas chromatograph: data from three replicates were used to draw the H2 calibration curve.

Anaerobic fermentation and biogas analysis

Anaerobic fermentations were carried out in 5-L continuously stirred tank reactors [73], and the fed-batch operational mode was used. The reactors were operated by using a pig manure and maize silage mixture [59] until the biogas production stabilized. This start-up period lasted for 4 to 5 weeks. Feeding with the various substrate compositions was started thereafter. One of the reactors was fed with a AB + S loading of 1 g oDM L−1 day−1, an identical reactor was supplied with AB + S and corn silage (0.5 + 0.5 g oDM L−1 day−1), and the control received only corn silage (1 g oDM L−1 day−1). The initial parameters of the substrates are summarized in Table 1. Heating was maintained by means of an electronically heated jacket which surrounded the cylindrical apparatus. Temperature was measured with a bimetallic sensor and was maintained constant at 37°C ± 1.0°C. The pH was between 7 and 8, and the redox potential was < −500 mV. The generated gas and its quality were measured daily after the 1-month start-up (weeks 1 to 4) and stabilization phase on the designated substrate. Gas volumes were measured with thermal mass flow devices (DMFC; Brooks Instrument, Hatfield, USA) attached to each gas exit port. The composition of the evolved biogas was measured with a gas chromatograph (6890 N Network GC System, Agilent Technologies, Santa Clara, USA) equipped with a 5 Å molecular sieve column (length 30 m, I.D. 0.53 megabore, film 25 μm). Ultrapure N2 was used as carrier gas.

Determination of fermentation parameters

oDM

The dry organic matter content was quantified by drying the biomass at 105°C overnight and weighing the residue giving the dry mass content. Further heating of this residue at 550°C provided the organic dry mass content.

Density measurement

Sample density was measured with a MINIDENS automatic density meter (Grabner Instruments, Wien, Austria).

C/N

To determine C/N, an Elementar Analyzer Vario MAX CN (Elementar Group, Hanau, Germany) was employed. The equipment works using the principle of catalytic tube combustion under an O2 supply at high temperatures (combustion temperature: 900°C, postcombustion temperature: 900°C, reduction temperature: 830°C, column temperature: 250°C). The desired components were separated from each other with the aid of specific adsorption columns (containing Sicapent (Merck, Billerica, USA), in C/N mode) and determined in succession with a thermal conductivity detector. Helium served as flushing and carrier gas.

NH4 +-N

For the determination of NH4 + ion content, the Merck Spectroquant Ammonium test (1.00683.0001) (Merck, Billerica, USA) was used. At the beginning of the experiment the NH4 + − N was 1,100 mg L−1.

VOAs/TAC

Five grams of fermenter sample was taken for the analysis and diluted to 20 g with distilled water. The subsequent process was carried out with Pronova FOS/TAC 2000 Version 812-09.2008 automatic titrator (Pronova, Berlin, Germany). At the beginning of the experiment the VOAs/TAC ratio was 0.2.

DNA isolation for metagenomic studies

Two-milliliter samples, taken from the reactors, were used for total community DNA isolation. The extractions were carried out with a slightly modified version of the Zymo Research kit (D6010, Zymo Research, Irvine, USA). Parallel samples from each reactor were lysed with three different lysis mixes (Table 2). After lysation (bead beating), the Zymo Research kit protocol was followed. The quantity of DNA was determined in a NanoDrop ND-1000 spectrophotometer (NanoDrop Technologies, Wilmington, USA) and a Qubit 2.0 Fluorometer (Life Technologies, Carlsbad, USA). DNA purity was tested by agarose gel electrophoresis and with an Agilent 2200 Tape Station (Agilent Technologies, Santa Clara, USA).

Table 2 Lysis conditions for total community DNA preparation

Next-generation DNA sequencing and data handling

The sample preparation for total metagenome sequencing of the pooled samples was carried out following the recommendations of the Ion Torrent PGM sequencing platform (Life Technologies, Carlsbad, USA). Sequencing was performed with Ion Torrent PGM 316 chips. The reads were analyzed and quality values were determined for each nucleotide. The 150 to 250 nucleotide-long individual sequences were further analyzed by using the MG-RAST software package [74], which is a modified version of Rapid Annotations based on Subsystem Technology (RAST). The MG-RAST server computes results against several reference datasets (protein and ribosomal databases) [75]. The generated matches to external databases were used to compute the derived data [59,76].

Abbreviations

A + S:

mixture of Chlamydomonas sp., and Scenedesmus sp., non-sulfur deprived

AB + S:

mixture of Chlamydomonas sp., Scenedesmus sp., and mutualistic bacteria, non-sulfur deprived

AD:

Anaerobic digestion

AE + S:

mixture of Chlamydomonas sp., Scenedesmus sp., and Escherichia coli ΔhypF, non-sulfur deprived

A-S:

mixture of Chlamydomonas sp., and Scenedesmus sp., sulfur deprived

oDM:

organic dry matter

TAC:

Total alkaline capacity

TAP:

TRIS-acetate-phosphate medium

TP:

TRIS-phosphate medium

VOS:

Volatile organic acids

References

  1. McKendry P. Energy production from biomass (Part2-3): conversion technologies. Biores Technol. 2002;83:47–63.

    Article  CAS  Google Scholar 

  2. Angelidaki I, Ellegaard L. Codigestion of manure and organic wastes in centralized biogas plants: status and future trends. Appl Biochem Biotechnol. 2003;109:95–105.

    Article  CAS  Google Scholar 

  3. Santosh Y, Sreekrishnan TR, Kohli S, Rana V. Enhancement of biogas production from solid substrates using different techniques—a review. Biores Technol. 2004;95:1–10.

    Article  Google Scholar 

  4. Goyal HB, Seal D, Saxena RC. Bio-fuels from thermochemical conversion of renewable resources: a review. Renew Sust Energy Rev. 2008;12:504–17.

    Article  CAS  Google Scholar 

  5. Schenk PM, Thomas-Hall SR, Stephens E, Marx UC, Mussgnug JH, Posten C, et al. Second generation biofuels: high efficiency microalgae for biodiesel production. Bioenergy Res. 2008;1:20–43.

    Article  Google Scholar 

  6. Johanson D, Azar CA. Scenario based analysis of land competition between food and bioenergy production in the US. Climate Change. 2007;82:267–91.

    Article  Google Scholar 

  7. Richmond A. Handbook of Microalgal culture: Biotechnology and Applied Phycology. Oxford: Blackwell Science; 2004.

    Google Scholar 

  8. Rodolfi L, Zitteli GC, Bassi N, Padovani G, Biondi N, Bonini G, et al. Microalgae for oil: strain selection, induction of lipid synthesis and outdoor mass cultivation in a low-cost photobioreactor. Biotechnol Bioeng. 2009;102:100–12.

    Article  CAS  Google Scholar 

  9. Edward M. The algal industry survey - a white paper by Dr. Mark Edward. In: Association with the Centre for Management Technology. 2009.

    Google Scholar 

  10. Singh J, Gu S. Commercialization potential of microalgae for biofuels production. Renew Sust Energy Rev. 2010;14:2596–610.

    Article  CAS  Google Scholar 

  11. Guccione A, Biondi A, Sampietro G, Rodolfi L, Bassi N, Tredici MR. Chlorella for protein and biofuels: from strain selection to outdoor cultivation in green wall panel photobioreactor. Biotechnol Biofuels. 2014;7:84. doi:10.1186/1754-6834-7-84.

    Article  Google Scholar 

  12. Posten C, Schaub G. Microalgae and terrestrial biomass as a source for fuels – a process view. J Biotechnol. 2009;142:64–9.

    Article  CAS  Google Scholar 

  13. Harun R, Singh M, Forde MG, Danquah KM. Bioprocess engineering of microalgae to produce a variety of consumer products. Renew Sust Energy Rev. 2010;14:1037–47.

    Article  CAS  Google Scholar 

  14. Chen P, Min M, Chen Y, Wang L, Li Y, Chen Q, et al. Review of biological and engineering aspects of algae to fuels approach. Int J Agric Biol Eng. 2009;2:1.

    Google Scholar 

  15. González-Delgado AD, Kafarov V. Microalgae based biorefinery: issues to consider. A review. CT&F - Ciencia Tecnología y Futuro. 2011;4:5–22.

    Google Scholar 

  16. Yen H-W, Hu I-C, Chen C-Y, Ho S-H, Lee D-J, Chang J-S. Microalgae based biorefinery - from biofuels to natural products. Biores Technol. 2013;135:166–74.

    Article  CAS  Google Scholar 

  17. Becker EW. Microalgae: Biotechnology and Microbiology. Cambridge, UK: Cambridge University Press; 1994.

    Google Scholar 

  18. Golueke CG, Oswald WJ, Gotaas HB. Anaerobic digestion of algae. Appl Microbiol. 1957;5:47–55.

    CAS  Google Scholar 

  19. Uziel M, Oswald WJ, Golueke CG. Solar energy fixation and conversion with algal-bacterial system. Washington, D.C: U.S. National Science Foundation Rep. No. NSF-RA-N-74-195, NSF; 1974.

  20. Keenan JD. Bioconversion of solar energy to methane. Energy. 1977;2:365.

    Article  CAS  Google Scholar 

  21. Binot R, Martin D, Nyns EJ, Naveau H. Digestion anaerobic d’algues cultivees dans les eaux de refroidissement industrielles. Martigues, France: Proc. Heliosynthese aquaculture Semin; 1977.

    Google Scholar 

  22. Samson R, Le Duy A. Biogas production from anaerobic digestion of Spirulina maxima algal biomass. Biotechnol Bioeng. 1982;24:1919.

    Article  CAS  Google Scholar 

  23. Becker EW. The production of microalgae a source of biomass. Biomass Util. 1983;67:205.

    Article  Google Scholar 

  24. Hernández EPS, Córdoba LT. Anaerobic digestion of Chlorella vulgaris for energy production. Res Con Recyc. 1993;9:127–32.

    Article  Google Scholar 

  25. Mussgnug JH, Klassen V, Schlüter A, Kruse O. Microalgae as a substrates for fermentative biogas production in a combined biorefinery concept. J Biotechnol. 2010;150:51–6.

    Article  CAS  Google Scholar 

  26. De Schamphelaire L, Verstraete W. Revival of the biological sunlight to biogas energy conversion system. Biotechnol Bioeng. 2009;103:296–304.

    Article  Google Scholar 

  27. JT, Tramp C, Sims RC, Miller CD. Characterization of a methanogenic community within an algal fed anaerobic digester. ISRN Microbiol. 2012. doi:10.5402/2012/753892.

  28. Melis A, Happe T. Hydrogen production. green algae as a source of energy. Plant Physiol. 2001;127:740–8.

    Article  CAS  Google Scholar 

  29. Zhang L, Happe T, Melis A. Biochemical and morphological characterization of sulfure-deprived and H2- producing Chlamydomonas reinhardtii (green alga). Planta. 2002;21:552–61.

    Article  Google Scholar 

  30. Fouchard S, Hemscheimer A, Caruana A, Pruvost J, Legrand J, Happe T, et al. Autotrophic and mixotrophic hydrogen photoproduction in sulfur-deprived Chlamydomonas reinhardtii cells. Appl Environ Microbiol. 2005;10:6199–205.

    Article  Google Scholar 

  31. Keshtacher-Liebso E, Hadar Y, Chen Y. Oligotrophic bacteria enhance algal growth under iron – deficient conditions. Amer Soc Microbiol. 1995;61:2411–39.

    Google Scholar 

  32. Watanabe K, Takihana N, Aoyagi H, Hanada S, Watanabe Y, Ohmura N, et al. Symbiotic association in Chlorella culture. FEMS Microbiol Ecol. 2005;51:187–96.

    Article  CAS  Google Scholar 

  33. Nikolaev YA, Plakunov YK, Voronina NA, Nemtseva NV, Platnikov AO, Gogoleva OA, et al. Effect of bacterial satellites on Chlamydomonas reinhardtii in an algo-bacterial community. Microbiology. 2008;77:78–83.

    Article  CAS  Google Scholar 

  34. Amin SA, Green DH, Hort MC, Küpper FC, Sunda WG, Carrano JC. Photolysis of ion – siderophore chelates promotes bacteria – algal mutualism. Proc Natl Acad Sci U S A. 2009;106:17071–6.

    Article  CAS  Google Scholar 

  35. Rivas MO, Vargas P, Riquelme CE. Interactions of Botryococcus braunii cultures with bacterial biofilms. Microb Ecol. 2010;60:628–35.

    Article  CAS  Google Scholar 

  36. Kazamia E, Czesnick H, Nguyen TTV, Croft MT, Sherwood E, Sasso S, et al. Mutualistic interaction between vitamin B-12 dependent algae and heterotrophic bacteria exhibit regulation. Environ Microbiol. 2012;14:1466–76.

    Article  CAS  Google Scholar 

  37. Xie B, Bishop S, Stessman D, Wright D, Spalding MH, Halverson LJ. Chlamydomonas reinhardtii thermal tolerance enhancement mediated by mutualistic interaction with vitamin B12-producing bacteria. ISME J. 2013;7:1544–55.

    Article  CAS  Google Scholar 

  38. Chwenk D, Nohynek L, Rischer H. Algae bacteria association inferred by 16S rDNA similarity in established microalgae cultures. Microbiol. 2014;3:356–68.

    Google Scholar 

  39. Kim B-H, Ramanan R, Cho D-H, Oh H-M, Kim H-S. Role of Rhizobium, a plant growth promoting bacterium, in enhancing algal biomass through mutualistic interaction. Biomas Bioenergy. 2014;69:95–105.

    Article  CAS  Google Scholar 

  40. Wu S, Li X, Yu J, Wang Q. Increased hydrogen production in co-culture of Chlamydomonas reinhardtii and Bradyrhizobium japonicum. Biores Technol. 2012;123:184–8.

    Article  CAS  Google Scholar 

  41. Lakatos G, Deák ZS, Vass I, Rétfalvi T, Rozgonyi Sz, Rákhely G, et al. Bacterial synbionts enhance photo-fermentative hydrogen evolution of Chlamydomonas algae. Green Chem. 2014. doi:10.1039/C4GC00745J.

  42. Maier T, Binder U, Böck A. Analysis of the hydA locus of Escherichia coli: two genes (hydN and hypF) involved in formate and hydrogen metabolism. Arch Microbiol. 1996;165:333–41.

    Article  CAS  Google Scholar 

  43. Melis A, Zhang L, Seibert M. Sustained photobiological hydrogen gas production upon reversible inactivation of oxygen evolution in the green alga Chlamydomonas reinhardtii. Plant Physiol. 2000;122:127–36.

    Article  CAS  Google Scholar 

  44. Ghirardi ML, Zhang L, Lee JW, Flynn T, Seibert M, Greenbaum E, et al. Microalgae: a green source of renewable H2. Trends Biotechnol. 2000;18:506–11.

    Article  CAS  Google Scholar 

  45. Kosourov SN, Batyrova KA, Petushkova EP, Tsygankov AA, Ghirardi ML, Seibert M. Maximizing the hydrogen photoproduction yields in Chlamydomonas reinhardtii cultures: the effect of the H2 partial pressure. Int J Hydrogen Energy. 2012;37:8850–8.

    Article  CAS  Google Scholar 

  46. Ward AJ, Lewis DM, Green FB. Anaerobic digestion of algae biomass: a review. Algal Res. 2014. doi:10.1016/j.algal.2014.02.001.

  47. Amon T, Gruber W, Hoffstede U, Jäger P, Jäkel K, Kaiser F, et al. Gasausbeute in landwirtschaftichen biogasanlagen. KTBL; 2010. ISBN:978-3-941583-49-9. BOKU University, Wien, Austria 2010

  48. McGhee TJ. A method for approximation of the volatile acid concentrations in anaerobic digesters. Water Sewage Works. 1968;115:162–6.

    CAS  Google Scholar 

  49. Nordmann W. Die Überwachtung der Schlammfaulunk. KA-Informationen für das Betriebspersonal, Beilage zur Korrespondenz Abwasser. 1977. 3/77.

  50. Alexander M. Biodegradation of organic chemicals. Environ Sci Technol. 1985;19:106–11.

    Article  Google Scholar 

  51. Chen Y, Cheng JJ, Creamer KS. Inhibition of anaerobic digestion process: a review. Biores Technol. 2008;99:4044–64.

    Article  CAS  Google Scholar 

  52. Nielsen HB, Angelidaki I. Strategies for optimizing recovery of the biogas process following ammonia inhibition. Biores Technol. 2008;99:7800–995.

    Google Scholar 

  53. Parkin GF, Owen WF. Fundamental of anaerobic-digestion of wastewater sludge. J Environ Eng. 1986;112:867–920.

    Article  CAS  Google Scholar 

  54. Yadvika S, Sreekrishnan TR, Kohli S, Rana V. Enhancement of biogas production from solid substrates using different techniques - a review. Biores Technol. 2004;95:1–10.

    Article  CAS  Google Scholar 

  55. Olsson J, Shadiimam MA, Nehrenheim E, Thorin E. Co-digestion of cultivated microalgae and sewage from municipal waste water treatment. International Conference on Applied Energy ICAE 2013 Jul. 1–4. 2013, Pretoria, South Africa, Paper ID: ICAE2013-518.

  56. Yen H-W, Brune DE. Anaerobic co-digestion of algal sludge and waste paper to produce methane. Biores Technol. 2007;98:130–4.

    Article  CAS  Google Scholar 

  57. Makarova K, Slesarev A, Wolf Y, Sarokin A, Mirkin B, Koonin E, et al. Comparative genomics of the lactic acid bacteria. Proc Natl Acid Sci USA. 2006;103:15611–6.

    Article  Google Scholar 

  58. Yamada Y, Yukphan P. Genera and species in acetic acid bacteria. Int J Food Microbiol. 2008;125:15–24.

    Article  CAS  Google Scholar 

  59. Wirth R, Kovács E, Maroti G, Bagi Z, Rakhely G, Kovacs KL. Characterization of a biogas-producing microbial community by short-read next generation DNA sequencing. Biotechnol Biofuels. 2012;5:1–16.

    Article  Google Scholar 

  60. Daniel RM, Smith M, Phillip AD, Ratcliffe HD, Drozd JW, Buel AT. Anaerobic growth and denitrification by Rhizobium japonicum and other Rihzobia. J Gen Microbiol. 1980;120:517–21.

    CAS  Google Scholar 

  61. Tjepkema J, Evans HJ. Nitrogen fixation by free-living Rhizobium in a defined liquid medium. Biochem Biophys Res Commun. 1975;65:625–8.

    Article  CAS  Google Scholar 

  62. Schlüter A, Bekel T, Diaz NN, Dondrup M, Eichenlaub R, Gartemann KH, et al. The metagenome of a biogas-producing microbial community of a production-scale biogas plant fermenter analyzed by the 454-pyrosequencing technology. J Biotech. 2008;136:77–90.

    Article  Google Scholar 

  63. Krause L, Diaz NN, Edwards RA, Gartemann K-H, Krömeke H, Neuwger H, et al. Taxonomic composition and gene content of a methane-producing microbial community isolated from a biogas reactor. J Biotech. 2008;136:91–101.

    Article  CAS  Google Scholar 

  64. Kröber M, Bekel T, Diaz NN, Goesmann A, Sebastian J. Phylogenetic characterization of a biogas plant microbial community integrating clone library 16S-rDNA sequences and metagenome sequence data obtained by 454-pyrosequencing. J Biotech. 2009;142:38–49.

    Article  Google Scholar 

  65. Stantscheff R, Kuever J, Rabenstein A, Seyfarth K, Dröge S, König H. Isolation and differentiation of methanogenic Archaea from mesophilic corn-fed on-farm biogas plants with special emphasis on the genus Methanobacterium. Appl Environ Biotechnol. 2014;98:5719–35.

    Article  CAS  Google Scholar 

  66. Ziganshina EE, Bagmanova AR, Khilyas IV, Ziganshin AM. Assessment of biogas-generating microbial community in a pilot-scale anaerobic reactor. J Biosci Bioeng. 2014;117:730–6.

    Article  CAS  Google Scholar 

  67. Sirohi SK, Pandey N, Singh B, Puniya AK. Rumen methanogens: a review. Indian J Microbiol. 2010;50:253–62.

    Article  CAS  Google Scholar 

  68. Rastogi G, Ranade DR, Yeole TY, Patole MS, Houche YS. Investigation of methanogen population structure in biogas reactor by molecular characterization of methyl-coenzyme M reductase A (mcrA) genes. Biores Technol. 2008;99:5317–26.

    Article  CAS  Google Scholar 

  69. Lee C, Kim J, Hwang K, O’Flaherty V, Hwang S. Quantitative analysis of methanogenic community dynamics in three anaerobic batch digesters treating different wastewaters. Water Res. 2009;43:157–65.

    Article  CAS  Google Scholar 

  70. Blume F, Bergmann I, Nettmann E, Schelle H, Rehde G, Munkdt K, et al. Methagenomic population dynamics during semi-continuous biogas fermentation and acidification by overloading. J Appl Microbiol. 2010;109:441–50.

    CAS  Google Scholar 

  71. Sialve B, Bernet N, Bernard O. Anaerobic digestion of microalgae as a necessary step to make microalgal biodiesel sustainable. Biotechnol Adv. 2009. doi:10.1016/j.biotechadv.2009.03.001.

  72. Lakaniemi A-M, Hulatt CJ, Thomas DN, Tuovinen OH, Puhakka JA. Biogenic hydrogen and methane production from Chlorella vulgaris and Dunaliella tertiolecta biomass. Biotechnol Biofuels. 2011;4:34.

    Article  CAS  Google Scholar 

  73. Kovács KL, Ács N, Kovács E, Wirth R, Rákhely G, Strang O, et al. Improvement of biogas production by bioaugmentation. BioMed Res Internat. 2013. http://dx.doi.org./10.1155/2013/482653.

  74. Meyer F, Paarmann D, D’Souza M, Olson R, Glass EM, Kubal M, et al. The metagenomics RAST server – a public resource for the automatic phylogenetic and functional analysis of metagenomes. BMC Bioinformatics. 2008;9:386.

    Article  CAS  Google Scholar 

  75. MG-RAST manual for version 3.3.6 revision 9. ftp://ftp.metagenomics.anl.gov/data/manual/mg-rast-manual.pdf.

  76. Kovács E, Wirth R, Maróti G, Bagi Z, Rákhely G, Kovács KL. Biogas production from protein-rich biomass: fed-batch anaerobic fermentation of casein and pig blood and associated changes in microbial community composition. PLoS One. 2013;8(10), e77265.

    Article  Google Scholar 

Download references

Acknowledgements

The authors thank Ms. Netta Bozóki for technical assistance. This work was supported by the domestic grants GOP-1.1.1-11-2012-0128, TÁMOP-4.2.2.A-11/1/KONV-2012-0007 and PIAC_13-1-2013-0145 and by the EU projects H2020-LCE-2014-3 646533 BIOSURF and ‘SYMBIOTICS’ ERC AdG to Éva Kondorosi.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Kornél L Kovács.

Additional information

Competing interests

The authors declare that they have no competing interests.

Authors’ contributions

RW and ZB developed the DNA extraction protocol, designed and performed the experiments, and contributed to the evaluation of metagenomic data. GL helped in the cultivation of the algal-bacterial biomass. GM organized and performed the DNA sequencing work. KLK and ZB conceived the project and participated in its design. RW and KLK drafted the manuscript. GR critically evaluated the manuscript. ÉK analyzed and revised the manuscript. JM and KN analyzed the data and participated in the writing of the manuscript. All authors read and approved the final manuscript.

Authors’ information

RW is a postdoctoral fellow at the Department of Biotechnology, University of Szeged, Szeged, Hungary. GL is a PhD student at the Department of Biotechnology, University of Szeged and Institute of Biochemistry, Hungarian Academy of Sciences, Szeged, Hungary. GM is Head of the Metagenomics Laboratory, Institute of Biochemistry, Biological Researh Center, Hungarian Academy of Sciences, Szeged, Hungary. ZB is an Assistant Professor at the Department of Biotechnology, while JM and KN are Full Professors at the Department of Oral Biology and Experimental Dentistry, University of Szeged. ÉK is Full Member of the Hungarian Academy of Sciences and a Senior Scientific Advisor at the Biological Research Center, Hungarian Academy of Sciences. RG is an Associate Professor, Department Chairman, and Director of the Environmental Research Institute at the University of Szeged. KLK is a Full Professor both at the Department of Biotechnology and at the Department of Oral Biology and Experimental Dentistry, University of Szeged; he is a Senior Scientific Adviser at the Institute of Biophysics, Biological Research Center, Hungarian Academy of Sciences. KLK serves as President of the Hungarian Biogas Association.

Roland Wirth and Gergely Lakatos contributed equally to this work.

Rights and permissions

Open Access  This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made.

The images or other third party material in this article are included in the article’s Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder.

To view a copy of this licence, visit https://creativecommons.org/licenses/by/4.0/.

The Creative Commons Public Domain Dedication waiver (https://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Wirth, R., Lakatos, G., Maróti, G. et al. Exploitation of algal-bacterial associations in a two-stage biohydrogen and biogas generation process. Biotechnol Biofuels 8, 59 (2015). https://doi.org/10.1186/s13068-015-0243-x

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/s13068-015-0243-x

Keywords